Cause
Soot build-up in the heater burner
Carbon accumulating in the combustion chamber and glow pin of a fuel-fired auxiliary heater, until it can no longer ignite or burn cleanly. These heaters are small burners with a glow pin, a metering pump and a combustion chamber, and soot is what they produce when combustion is imperfect.
Short run cycles are what cause it, which is the useful part. A heater started and stopped before it reaches full temperature never burns off its own deposits, so the fouling accumulates every cycle. A heater used for ten minutes to clear a windscreen and switched off is being used in the way that fouls it fastest, and a periodic long run is genuinely preventative.
The fault presents as failure to start or as a shutdown shortly after ignition, with the module reporting a flame that was not detected or was lost. Check the exhaust and intake pipes for the heater as well — they are small-bore, they run under the vehicle, and a blocked or crushed one produces the same incomplete combustion that causes the soot in the first place.
Typically a moderate job.
Codes this can cause (3)
Codes where this is a likely explanation first, rather than merely a possible one.
Information, not instruction
CarGeek is a reference, not a service manual. Its pages are written from public sources and from what other people have found, never from a manufacturer's own service information, so they can be wrong or incomplete for your particular vehicle. Some of what they describe carries real risk: high voltage, fuel under pressure, stored energy, hot and moving parts.
Have anything you intend to act on checked by a trained person against the manufacturer's own procedure for your vehicle. Nothing here replaces that procedure.
Others who found this
Be the first to write this up
Nothing posted about this yet. Whatever you found is worth writing down — even a dead end saves someone the same afternoon.
What makes one worth reading:
- The car — make, model, year and engine. The same fault behaves differently on each.
- What you measured, not only what you replaced.
- What actually fixed it — or that nothing did, which is worth knowing too.
Sign in or create an account to add what you found about Soot build-up in the heater burner.