P04D0: Датчик температуры рециркуляции выхлопных газов C — низкий уровень в цепи
Что делать
Ask for the wiring near the exhaust and EGR cooler to be inspected before the sensor is replaced. On this kind of sensor a short to earth reads exactly like an impossibly hot sensor, and a wire chafed against a hot pipe is the usual cause — much cheaper than a part.
Mention if the fault comes and goes with the weather. Appearing in the wet and clearing when dry points firmly at water in a connector.
Ask which part of the system this third sensor watches on your engine, since it varies and the answer decides where the garage looks.
The car will usually drive normally, but the emissions system will not be working as intended.
Что означает этот код
The third EGR temperature sensor's signal is below the lowest voltage the circuit should produce.
A third EGR temperature sensor means a more complex recirculation system than most, and identifying what it watches is the first step. Two arrangements are common: an engine with both high-pressure and low-pressure EGR, where each path is monitored separately, or a V engine with a cooler per bank.
On these thermistor circuits, low voltage means the opposite of what it sounds like. Resistance falls as temperature rises, so a low signal corresponds to a very hot sensor — and a short to ground produces the same reading as an impossibly hot one. They are electrically identical.
So a circuit-low code on a temperature sensor almost always means a short, not heat. Check the wiring before believing the temperature.
Location makes shorts likely here. These sensors and their harnesses run close to the exhaust and the cooler, where insulation hardens and eventually fails against the metal it is resting on. A wire chafed against a hot pipe is the classic finding.
Water in the connector does the same thing and is why the fault often appears in wet weather and clears in dry.
Unplugging the sensor separates wiring from element in a minute: a circuit that stays low with the sensor disconnected is a harness fault.
Вероятные причины
Начните отсюда
- Проводка замкнута на массу · ремонт средней сложности
- Тепловое повреждение изоляции проводки · ремонт средней сложности
- Проникновение воды в разъём · простой ремонт
- Разъём окислен или неплотно посажен · простой ремонт
Встречается реже
- Неисправный датчик температуры EGR · ремонт средней сложности
Симптомы
Задействованные компоненты
Информация, а не инструкция
CarGeek — это справочник, а не руководство по ремонту. Его страницы составлены по открытым источникам и по опыту других людей, но не по сервисной документации производителя, поэтому для вашего конкретного автомобиля они могут быть неверными или неполными. Часть описанного связана с реальной опасностью: высокое напряжение, топливо под давлением, накопленная энергия, горячие и движущиеся детали.
Всё, по чему вы собираетесь действовать, сначала проверьте с человеком, имеющим техническую подготовку, по собственной процедуре производителя для вашего автомобиля. Ничто здесь не заменяет эту процедуру.
Опыт сообщества
Напишите об этом первым
Об этом пока ничего не опубликовано. Всё, что вы выяснили, стоит записать — даже тупиковый путь сэкономит кому-то те же полдня.
Что делает такой отчёт полезным:
- Автомобиль — марка, модель, год и двигатель. Одна и та же неисправность ведёт себя на каждом по-своему.
- Что вы измерили, а не только что заменили.
- Что действительно помогло — или что не помогло ничто, это тоже стоит знать.
Войти или создать учётную запись для добавления того, что вы выяснили по теме P04D0.