U0425: Ungültige Daten vom Steuergerät der Zusatzheizung empfangen
Was zu tun ist
The car drives normally. The auxiliary or parking heater will not run, and that refusal is deliberate — a fuel-burning heater is heavily supervised, and when it cannot verify what it is doing it shuts down rather than continuing. It will not run unattended with a fault, which is the right way round.
Expect a cold cabin and slow warm-up in winter, which on a diesel can be a genuine inconvenience rather than a small one.
Two things worth asking for.
Does it need a lockout reset? These heaters lock themselves out after several failed attempts to light, on purpose, so they do not keep pumping fuel into a hot exhaust. That reset needs a scan tool, and skipping it leaves the heater dead even after the real fault is fixed.
Has the burner been serviced? These units soot up, particularly if used for short runs, and a burner that cannot light cleanly is the commonest actual cause. Cleaning it is the repair — not a new module, which is the expensive answer to a maintenance problem.
Was dieser Code bedeutet
The auxiliary heater control module is broadcasting data that cannot be accepted as true. See U0400 for the family's framing.
An auxiliary heater is a small burner that burns the vehicle's own fuel to make heat, fitted to diesels whose engines produce too little waste heat to warm a cabin quickly, and to vehicles offering pre-heating before the driver gets in. The fact that it burns fuel, often while the vehicle is unattended, is why this code is filed as serious rather than as a comfort matter.
These heaters are supervised carefully for exactly that reason. The module monitors flame presence, combustion temperature, the glow element, the fuel pump and the exhaust, and it shuts down on anything it cannot verify. So an implausible report normally results in the heater refusing to run — which is protection, and the correct behaviour.
What must not happen is a heater that runs unsupervised, and the vehicle is built so it cannot. That is worth saying plainly to anybody worried about a fuel-burning device with a fault: the failure direction is off, not on.
Two practical points follow.
A heater that has locked out often needs a deliberate reset rather than just a code clear. Many designs lock out permanently after a number of failed ignition attempts, specifically to stop repeated attempts pumping unburnt fuel into a hot exhaust. A scan tool reset is part of the repair, and one skipped leaves the heater dead on perfectly good hardware.
And soot is the usual real cause. The corpus already names soot build-up in the heater burner — these units coke up, especially where they are used for short periods or run on poor fuel, and a burner that will not light cleanly reports combustion values that cannot be reconciled. Servicing the burner is the repair, not replacing the module.
Wahrscheinliche Ursachen
Hier anfangen
- Rußablagerung im Brenner des Heizgeräts · Fachwerkstatt
- Kraftstoffbetriebenes Heizgerät defekt · Fachwerkstatt
- Kraftstoffzufuhr zum Heizgerät verstopft · mittel
- Korrodierter oder loser Stecker · einfach
Seltener
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu U0425.