U0325: Softwareinkompatibilität mit dem Steuergerät der Zusatzheizung
Was zu tun ist
The auxiliary heater will not run properly, and there is one safety point that matters more than the inconvenience.
These heaters burn fuel and have their own exhaust, so they produce carbon monoxide. Never run one in a garage or any enclosed space, and if it starts when it should not, or refuses to shut down, have it isolated rather than living with it. If this is a motorhome or anything people sleep in, treat that as urgent.
Otherwise nothing is broken — two computers are running software that does not belong together, which is a programming job.
If your heater was fitted after the car or van was built, go back to the installer rather than the main dealer. They fitted that module and hold its configuration, and a dealer updating the factory software again will not fix a mismatch on the aftermarket side.
And here is the commonest way this happens, with nobody at fault. The vehicle went to a dealer, the factory software was updated under a service action, and the heater's computer was left on the version it was installed with. If it has been to a dealer recently, mention it — that is very likely the whole story.
Expect cold starts and a cold cabin until it is sorted, which on a diesel also means more soot into the particulate filter.
Was dieser Code bedeutet
A module is running software that does not belong with the auxiliary heater control module's. See U0300 for the family and U0166 for what an auxiliary heater is and why it matters beyond comfort.
This code has a dominant cause that most of the family does not, and it is the same one as U0309: a retrofit.
Fuel-burning parking heaters are very often fitted after the vehicle was built — by a specialist, on a van, a motorhome, a caravan conversion or a cold-climate car — and the heater's own module has to agree with the vehicle about when it may run, what the coolant temperature is, whether the fuel level permits it and how the timer and remote are handled. That agreement is software on both sides.
So the commonest route is a vehicle whose factory software was updated while the retrofit's was not — a dealer visit, a recall, a module replacement — with nobody at fault and the two halves simply no longer matching. The installer is usually the right first call, since a dealer updating the factory side again cannot resolve a mismatch on the aftermarket side.
One safety point belongs on any page about a fuel-burning heater and does not soften for a configuration fault. These units have their own exhaust and produce carbon monoxide. A heater whose control agreement is uncertain must not be left to run unattended, and never in a garage or an enclosed space. If it starts when it should not, or will not shut down, isolate it rather than living with it — and on a vehicle people sleep in, treat that as urgent rather than inconvenient.
On a factory-fitted system the usual family rules apply and it is a dealer calibration job.
Wahrscheinliche Ursachen
Hier anfangen
- Nachgerüstete Ausstattung nicht konfiguriert · Fachwerkstatt
- Software nur an einem Steuergerät aktualisiert · Fachwerkstatt
- Falsche Konfiguration des Steuergeräts nach dem Tausch · Fachwerkstatt
Seltener
- Steuergerät nicht auf das Fahrzeug codiert · Fachwerkstatt
- Schlechte Leitungsverbindung in einem nachträglichen Einbau · mittel
- Softwarekalibrierung veraltet · Fachwerkstatt
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu U0325.