P0E16: Kühlmittelheizung B des Batteriepakets — Steuerstromkreis unterbrochen
Was zu tun ist
You may notice nothing until the weather turns cold. Then expect reduced range, weak acceleration, little regenerative braking and slow rapid charging — and note that this looks exactly like a worn-out battery. If the car is normal in warm weather, it is not the pack. Preconditioning while still plugged in helps in the meantime.
Was dieser Code bedeutet
The control circuit for the traction battery's coolant heater is faulty.
A traction battery has a heater, and most people do not know it — including a lot of the people who diagnose them.
A lithium pack works badly cold, and the reason is physical rather than electronic: the lithium ions move through the electrolyte more slowly at low temperature, so the pack's internal resistance rises steeply. Below about ten degrees the car must limit both how much power it takes out and how much it puts in — which is why an electric car in winter is slower, has less regenerative braking and rapid-charges at a fraction of its summer rate. The argument for why forcing charge into a cold pack is genuinely damaging is at P0CA6.
So the car heats the pack, using a coolant heater in the battery's thermal circuit, typically before a scheduled departure and while preconditioning for a rapid charge. This is the code family for that heater.
Its failure is invisible for half the year and then transforms the car. Summer: nothing. Winter: reduced range, weak acceleration, no regenerative braking for the first miles, and a rapid charger delivering a fraction of its rating — on a vehicle with no other fault, whose owner concludes the battery is worn out. A heater fault and a genuinely aged pack present almost identically in January, and the discriminator is what happens in July.
A second heater implies a pack large enough to need two, which also means losing one is a partial failure: heating still happens, at half the rate. So the symptoms are milder and easier to attribute to cold weather being cold — the car warms up eventually, just far too slowly to help a morning commute.
The control circuit is open — no drive reaching the heater.
Wahrscheinliche Ursachen
Hier anfangen
- Heizer für Batteriekühlmittel defekt · Fachwerkstatt
- Leitungsbruch in der Steuerleitung · Fachwerkstatt
- Korrodierter oder loser Stecker · Fachwerkstatt
Seltener
- Endstufe des Steuergeräts defekt · Fachwerkstatt
- Kabelbaum beschädigt · Fachwerkstatt
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu P0E16.