P0D25: Vorladung des Ladesystems — Zeit zu kurz
Was zu tun ist
The car will usually still drive and may still charge. Have it looked at before relying on it — this code can mean a contactor is not opening properly, which is a fault that gets worse and is far cheaper to catch early than to repair once a contactor has welded.
Was dieser Code bedeutet
The charging system's precharge completed faster than it should have.
The charging system has a precharge of its own, and it is not the pack's. The main precharge at P0C74 protects the drive inverter. This one protects the charger's own capacitors when the charging contactors close. Both exist for the same reason: closing a contactor straight onto a large empty capacitor draws an enormous inrush current for an instant — enough to weld the contacts together — so a resistor is put in the path first to fill the capacitor gently, and only then is the main contactor closed across it.
"Too short" is the more alarming of the two directions, which is not obvious. Precharge finishing early means the capacitor reached voltage faster than the resistor should allow, and there are only two ways that happens: the capacitor was already charged — meaning a contactor did not open when it was told to, and may be welded — or the resistor is no longer in the path, shorted or bypassed. Either way the protection precharge exists to provide is not there any more.
So this is a code to act on before the next charge rather than after, because the failure it warns about is the one that welds a contactor shut permanently.
Wahrscheinliche Ursachen
Hier anfangen
- Batterieschütz verschweißt · Fachwerkstatt
- Vorladewiderstand ausgefallen · Fachwerkstatt
- Batterieschütz defekt · Fachwerkstatt
Seltener
- Korrodierter oder loser Stecker · Fachwerkstatt
- Steuergerät ausgefallen · Fachwerkstatt
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu P0D25.