P045E: Abgasrückführung B — Ansteuerung klemmt offen
Was zu tun ist
Say whether the engine idles roughly or stalls when you come to a stop but feels fine at speed. That pattern fits this fault exactly and is the most useful thing you can report.
Ask whether the valve can be cleaned rather than replaced. Carbon build-up is the usual cause, these valves are expensive, and one that frees up and holds position afterwards has been genuinely repaired.
Mention any black smoke, particularly when pulling away.
A pattern of short journeys makes this much worse. Regular longer runs at sustained speed keep the recirculation system considerably cleaner, and are worth building into how the car is used once it is fixed.
Was dieser Code bedeutet
The second EGR valve is stuck open, recirculating exhaust gas when it should not be.
A second EGR valve usually means the engine has two recirculation paths, and knowing which is which shapes the diagnosis. High-pressure EGR takes gas from before the turbine and feeds it after the compressor — fast-acting, hot, and used at low load. Low-pressure EGR takes gas from after the particulate filter and feeds it before the compressor — cooler, cleaner, and used at higher load.
Valve B is commonly the low-pressure one, though it can be a second bank's valve on a V engine, so confirm before diagnosing.
Stuck open is the direction that causes real driveability complaints. At idle and on light throttle the engine should be getting little or no recirculated gas — it needs clean air to burn stably. A valve stuck open dilutes the charge at exactly the wrong moment, which produces a rough, hunting idle, hesitation when pulling away, black smoke, and in the worst case a stall at junctions.
A driver reporting 'it idles badly and stalls when I come to a stop, but it is fine on the motorway' is describing this precisely.
Carbon is the cause in the overwhelming majority of cases. A low-pressure valve sits in a cooler, wetter gas stream, so its deposits are more like a sticky sludge than dry soot — which is why it binds rather than jams solid, and why cleaning often genuinely works.
Wahrscheinliche Ursachen
Hier anfangen
- Rußablagerungen im AGR-System · mittel
- AGR-Ventil hängt oder ist festgefressen · mittel
Seltener
- AGR-Kanal verstopft · mittel
- Rückstellfeder des Ventils gebrochen · mittel
- Wicklung des Magnetventils unterbrochen oder kurzgeschlossen · mittel
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu P045E.