P20FB: AdBlue-Pumpe B — Funktion der Ansteuerung oder klemmt ausgeschaltet
Was zu tun ist
Ask whether this vehicle has two dosing points or a transfer pump feeding a smaller tank, since the same code means different things depending on the layout and it decides what gets checked.
Ask how the other pump is behaving. If the first pump is working normally and only this one is not, the fault is local to it — but if both are struggling, the cause is usually the fluid or a shared blockage, and no pump needs replacing.
Mention the weather if it is cold, since partly frozen fluid stops a pump delivering with nothing broken.
On a working vehicle, be aware it may seem fine unladen and still fail its emissions target under load, so do not judge by how it drives.
Was dieser Code bedeutet
The second reductant pump is not delivering when commanded, or is stuck off.
A second reductant pump means a larger system than a passenger car's, and identifying what it serves is the first step. Two arrangements are common: a heavy vehicle with two dosing points — one before each of two catalyst sections — or a system where a transfer pump moves fluid from a main tank to a smaller dosing tank while a second pump does the metering.
Those are different enough that the same code means different things, so establish which this vehicle has before diagnosing.
The causes are its sibling's: crystallisation, a blocked filter, frozen fluid, a worn pump, or an electrical fault upstream.
What a second pump adds is a control, and it is a good one. Pump A and pump B do the same job with the same fluid from the same tank. If A is working and B is not, the fault is local to B — its wiring, its filter, its own crystallisation. If both are struggling, the fluid or the shared supply is the problem, and no pump needs replacing.
That comparison is worth making explicitly before ordering a part, because these pumps are not cheap and the shared causes — frozen fluid, contaminated fluid, a blocked main filter — are much cheaper to put right.
On commercial vehicles, note that dosing capacity is sized for the duty. A vehicle running with one pump down may appear fine unladen and fail its emissions target under load.
Wahrscheinliche Ursachen
Hier anfangen
- AdBlue-Injektor auskristallisiert · mittel
- AdBlue-Pumpe defekt · mittel
- AdBlue-Filter verstopft · mittel
Seltener
- AdBlue im Tank oder in den Leitungen eingefroren · mittel
- Korrodierter oder loser Stecker · einfach
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu P20FB.