P0D6D: Spannung A des Motors des Klimakompressors — Niedrig
Was zu tun ist
No air conditioning, and no cabin heating on a heat-pump car. The car will drive. This is a high-voltage supply fault rather than a compressor fault, so a replacement compressor would not fix it.
Was dieser Code bedeutet
The supply voltage at the electric air conditioning compressor's motor is below its lower limit.
This is a reading, not an instrument, and the corpus draws that line everywhere. P0D68 says the sensor's circuit is faulty. This one says the sensor is working and the voltage really is low — which points away from the compressor and back up its supply: the high-voltage fuse feeding it, the cable, the connection, or a pack that is itself sagging under load.
An electric car's air conditioning compressor is a high-voltage machine, and almost everything that follows from that surprises people who know conventional systems.
A belt-driven compressor stops when the engine stops. That is tolerable on a petrol car because the engine only stops when the car does. On a hybrid the engine stops at every set of lights, and on an electric car there is no engine at all — so the compressor has to be driven by its own motor, fed from the traction pack at several hundred volts, with its own inverter to turn that direct current into the three-phase supply the motor needs. That inverter is why this block has phase current codes for an air conditioning part.
Two consequences change what a fault here means. First, on many cars this same compressor cools the battery, so an air conditioning failure becomes a charging and power failure in warm weather — the driver reports a hot cabin and the car quietly reports reduced rapid-charging. Second, a heat pump runs this compressor in reverse to heat the cabin, so on a car with one, losing the compressor loses the heating too, in winter, when nobody suspects air conditioning.
And the repair carries a hazard that has no equivalent on a conventional system: the oil. A high-voltage compressor is lubricated by a specific non-conductive polyolester oil carried in the refrigerant. The PAG oil used in every belt-driven system absorbs moisture and conducts — put it into a high-voltage compressor and it degrades the motor's insulation, which can energise the refrigerant circuit and the metal pipework running through the car. This is a real and repeated workshop error, not a theoretical one, and it is the reason these systems must be serviced with dedicated equipment that has never seen PAG oil.
Wahrscheinliche Ursachen
Hier anfangen
- Korrodierter oder loser Stecker · Fachwerkstatt
- Sicherung durchgebrannt oder Versorgung ausgefallen · Fachwerkstatt
- Kabelbaum beschädigt · Fachwerkstatt
Seltener
- Elektrischer Klimakompressor defekt · Fachwerkstatt
- Isolierung des Hochvoltkabels beschädigt · Fachwerkstatt
Symptome
Beteiligte Bauteile
Information, keine Handlungsanweisung
CarGeek ist ein Nachschlagewerk, kein Werkstatthandbuch. Die Seiten entstehen aus öffentlichen Quellen und aus dem, was andere festgestellt haben, nie aus den Serviceunterlagen des Herstellers; für Ihr konkretes Fahrzeug können sie daher falsch oder unvollständig sein. Ein Teil des Beschriebenen birgt echte Gefahren: Hochspannung, Kraftstoff unter Druck, gespeicherte Energie sowie heiße oder bewegte Teile.
Lassen Sie alles, wonach Sie handeln wollen, von einer fachlich geschulten Person anhand der herstellereigenen Vorgehensweise für Ihr Fahrzeug prüfen. Nichts hiervon ersetzt diese Vorgehensweise.
Erfahrungen der Community
Schreiben Sie den ersten Erfahrungsbericht dazu
Dazu wurde noch nichts veröffentlicht. Was immer Sie gefunden haben, ist es wert, aufgeschrieben zu werden — selbst eine Sackgasse erspart jemandem denselben Nachmittag.
Was einen Bericht lesenswert macht:
- Das Fahrzeug — Marke, Modell, Baujahr und Motor. Derselbe Fehler verhält sich auf jedem anders.
- Was Sie gemessen haben, nicht nur, was Sie getauscht haben.
- Was es tatsächlich behoben hat — oder dass nichts es behoben hat, was ebenso nützlich ist.
Anmelden oder ein Konto anlegen und eintragen, was Sie gefunden haben — zu P0D6D.